Product ID:ENAMEL, GLOSS BLUE 15044
MSDS Date:09/28/1999
FSC:8010
NIIN:01-433-8374
Status Code:A
MSDS Number: CKXSW

SHERWIN-WILLIAMS CO THE

101 PROSPECT AVE NW
CLEVELAND, OH 44115-1042
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2242

Preparer: ERNEST CARTER

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

MINERAL SPIRITS

CAS: 64742-88-7

OSHA PEL 100 PPM

ACGIH TLV: 100

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL see Table Z-2

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 100 PPM

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LIGHT AROMATIC SOLVENT NAPHTHA (PETROLEUM)

CAS: 64742-95-6

RTECS: WF3400000

1,3,5-TRIMETHYLBENZENE

CAS: 108-67-8

RTECS: OX6825000

OSHA PEL 25 PPM

ACGIH TLV: 25 PPM

1,2,4-TRIMETHYLBENZENE

CAS: 95-63-6

RTECS: DC3325000

OSHA PEL 25 PPM

ACGIH TLV: 25 PPM

COBALTOUS 2-ETHYLHEXANOATE

CAS: 136-52-7

1-METHOXY-2-PROPANOL ACETATE, 108-67-8

KAOLIN

CAS: 1332-58-7

RTECS: GF1670500

OSHA PEL 15 MG/M3

ACGIH TLV: 2 MG/M3

TALC

CAS: 14807-96-6

RTECS: WW2710000

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 2 MG/M3

CALCIUM CARBONATE

CAS: 471-34-1

RTECS: FF9335000

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHALATION AND/OR
SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF USE. TO MINIMIZE,
FOLLOW RECOMMENDATIONS FOR PROPER USE, VENTILATION,AND PERSONAL
PROTECTIVE EQUIPMENT.IRRITATION O F EYES, SKIN AND RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION.EXTREME OVEREXPOSURE
MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH.
Effects of Overexposure:HEADACHE,DIZZINESS,NASEA,AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS.REDNESS AND ITCHING OR BURING SENSATION MAY INDICATE
EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

First Aid:IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE COMTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. FLUSH EYES
WITH LA RGE AMOUNTS OF WATER FOR 15 MINUTES. GET MEDICAL ATTENTION.
GET MEDICAL ATTENTION.

Flash Point Method:CALC
Flash Point:=37.8C, 100.F
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER
MAY BE USED TO COOL CLOSED CO NTAINERS TO PREVENT PRESSURE BUILD-UP
AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.APPLICATION TO
HOT SURFACES REQUIRES SPECIAL PRECAUTIONS.DURING EMERGENCY
CONDITIONS OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD.L ATTENTION.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.

Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT AND OPEN FLAME. CONSULT NFPA CODE. USE APPROVED BONDING
AND GROUNDING. BROCEDURES. KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAI NERS WITH COMPLETE AND APPROPRIATE
LABELING. DO NOT TEKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION.WEAR A PROPERLY FITTED ORGANTIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION
AGAINST MATERIALS. W HEN SANDING OR ABRDING THE DRIED FILM, WEAR A
DUST/MIST RESPIRATOR UNDERLYING PAINT, OR THE ABRASIVE.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO MATERIALS IN SECTION11 IS MAINTAINED BELOW APPLICABLE
EXPOSURE LIMITS.
Protective Gloves:WEAR GLOVES WHICH ARE RECOMMENDED BY GLOVE SUPPLIER
FOR PROTECTION.
Eye Protection:WEAR SAFETY SPECTACLES WITH UNPERFORATED SIDESHIELDS.
Supplemental Safety and Health

Boiling Pt:B.P. Text:281-395
Vapor Density:HEAVIER
Spec Gravity:1.1-1.4
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:35-45

Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE
Conditions to Avoid Polymerization:WILL NOT OCCUR

Waste Disposal Methods:WASTE FROM THIS PRODUCT MAY BE HAZARDOUS AS
DEFINED UNDER THE RESOURCE CONSERVATION AND RECOVERY ACT (RCRA) 40
CFR 261. WASTE MUST BE TREATED FOR IGNITABILITY TO DETERMINE THE
APPLICABLE EPA HAZARDOUS WASTE NUMBERS.

Toxicological Information:BASED ON BEST CURRENT INFORMATION, THERE IS
NO KNOWN HUMAN SENSITIZATION ASSOCIATED WITH THIS PRODUCT. THERE IS
NO KNOWN TOXICOLOGICALLY SYNERGISTIC PRODUCTS ASSOCIATED WITH THIS
PRODUCT. CARCINOGENIC ITY: NO ANIMAL SKIN CARCINOGENICITY TESTS OF
THESE MATERIALS HAVE BEEN CONDUCTED. NITHER IARC, NTP, ACGIH, NOR
OSHA HAVE CLASSIFIED THESE MATERIALS AS TO THEIR CARCINOGENIC RISK.
BASED ON CURRENT INFO RMATION , THERE IS NO KNOWN REPRODUCTIVE
TOXICITY ASSOCIATED WITH THIS PRODUCT, AND NO KNOWN TERATOGENICITY
ASSOCIATED WITH THIS PRODUCT. EXPERIMENTAL EVIDENCE SUGGESTS THIS
PRODUCT DOES NOT CAUSE MUT AGENESIS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:ECOTOXICITY: NOT AVAILABLE. USEPA WASTE: NOT REGULATED. THIS
PRODUCT , IF DISCARDED, IS NOT EXPECTED TO BE A CHARACTERISTIC
WASTE. IF RECYCLED IN THE USA, IT MUST BE MANAGED IN ACCORDING WITH
40 CFR P ART 279. PROCESSING, USE, OR CONTAMINATION MAY MAKE THIS
INFORMATION INAPPROPRIATE, INACCURATE, OR INCOMPLETE.CANADIAN
ENVIRONMENTAL PROTECTION ACT (CEPA): THIS PRODUCT IS NOT FOR SALE
OR USE IN CANA DA.

Transport Information:DOT: NOT REGULATED. TDG: THIS PRODUCT IS NOT FOR
SALE OR USE IN CANADA.

SARA Title III Information:108-88-3, TOLUENE, 1% MAX; 1330-20-7,
XYLENE, 1% MAX; 95-63-6, 1,2,4-TRIMETHYLBENZENE, 8% MAX.; COBALT
COMPOUND, .2% BY WEIGHT.
State Regulatory Information:SARA 313 (40 CFR 372.65 C) SUPPLIER
NOTIFICATION